One of the big reasons your golf cart could quit on you is that your motor burnt out. Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside.
What causes a golf cart to overheat?
Cable corrosion, which is a result of a battery leaking battery acid, can cause overheating in the wires on your golf cart. The corroded cables will cause a higher resistance while transmitting power which leads to the heating of the terminals, cables, and batteries.
How do you cool a golf cart engine?
Re: Golf Cart Motor overheating
The guys that race (very high speed) electric and also 2 stoke Radio Control boats use water to cool the motors / engines. Try some small diameter copper tube around the outside of the motor, one end is under water facing forward, the other exits behind.
Is there a reset button on an electric golf cart?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How long can you run an electric golf cart?
Street legal golf carts run 20-25 miles per hour. If your electric cart is running 25 mph, with a 35 mile range, and you put your foot on the pedal and drive non stop around town, the simple math shows you will get 80 to 90 minutes of run time.
42 related questions foundShould I leave my golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
What can go wrong with an electric golf cart?
5 Common Electric Golf Cart Problems and How to Solve Them
- Troubleshooting Batteries. Like any electric vehicle, the battery is often the root of the problem. ...
- Ignition or Motor Issues. ...
- Solenoid Woes. ...
- Faulty Direction Switch. ...
- No Speed Control.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my golf cart controller is bad?
When your golf cart's speed controller isn't operating correctly, your cart will show it by running erratically or failing to drive at one constant speed. If your cart starts showing these symptoms, the first thing you should look at is your speed controller.
How do I know if my EZ GO controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
How hot does a golf cart muffler get?
Most mufflers would deal with temperatures which range between 300 and 500 degrees Fahrenheit. Because of the heat intensity being produced by the emission system of the engine, most of the exhaust systems are indeed built to handle an excess of almost 1200 degrees.
Why is my gas powered golf cart smoking?
Worn Out or Broken Piston
The pistons on your golf cart help produce power by compressing your fuel and moving when the spark plug ignites the gas. However, these pistons can get broken or worn down and run improperly. When this happens, your cart is likely to produce a lot of excessive smoke whenever it runs.
How do you reset a golf cart electric motor?
Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button. Push the button to reset the motor.
What causes a electric golf cart to jerk?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
What happens when golf cart solenoid goes bad?
If the solenoid is broken and not working correctly, you may notice your golf cart won't start, picking up speed, or even working at all (issues with acceleration could also be caused by a bad speed controller).
When Should golf cart batteries be replaced?
If you notice that the best golf cart batteries are taking even longer to charge, it's time to replace them. Battery cells will eventually break down over time. The charging power moving through the battery won't be as effective as before. Some batteries may never fully charge at some point.
How long do golf cart batteries last?
That all being said, properly maintained battery packs in fleet carts tend to last about 4-6 years while private owners tend to get about 6-10 years out of their battery packs. Other major factors include the type of options on the cart that may increase the draw from the battery pack.
How long will a 48v golf cart run?
How Long Will a 48 Volt Golf Cart Run? A 48 volt golf cart, depending on its amperage can go from 12 miles to 35 miles.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Are electric golf carts better than gas?
Reliability: Both carts are very reliable, but newer electrics do generally last longer than gas. On an electric cart, there are fewer parts and therefore fewer parts to go bad. with a gas cart, you have clutches, carb, fuel pump, belts, valves, starter and more.
Does an electric golf cart have a transmission?
Unlike your automobile, electric carts do not have a transmission or clutch.
Does it hurt to leave golf cart plugged in?
Final Thoughts. No, it's not recommended that you leave your golf cart plugged in all the time. Although automatic chargers are designed to prevent over-charging, there is still the risk of the circuit breaker tripping, which would result in damage to your battery's cells.
What happens if you overcharge golf cart batteries?
An overcharged golf cart battery will boil the distilled water mix and sulfuric acid. The casing of the battery can steadily get heated up and become hot to the touch. Equally, it may begin to swell or melt as flammable hydrogen builds up inside the sealed cells.
How often should you fill golf cart batteries with water?
The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
