How do you remove the governor on a EZ Go golf cart?

General Instructions

1. Detach the cable from the carburetor. The cable is about the width of a straw. ...
2. Follow the disconnected cable up to the governor. ...
3. Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ...
4. Using your wrench, remove the bolt on the gas pedal shaft.

How do I make my EZ Go gas golf cart go faster?

One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.

How can I make my electric EZ Go golf cart go faster?

Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.

How can I make my golf cart governor faster?

If you find this rod, then your governor can be easily adjusted by accessing the cart's inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart's governance to increase the overall speed.

How fast can a golf cart go without a governor?

Consider Replacing Your Speed Control

A typical electric cart without an upgraded speed control tops out around 12 mph. If you go this route, anticipate an upgrade cost around $700.

How do I adjust my EZ Go carburetor?

2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.

How do I speed up my 36V EZ Go?

How to Make a 36 Volt Golf Cart Faster

1. Remove any unnecessary additions, racks or parts on your golf cart. ...
2. Power-wash your cart. ...
3. Check the shaft under the ignition pedal. ...
4. Put larger tires on the cart. ...
5. Replace any old or worn-out parts that are causing the cart to move slower than it should.

Is 30 mph fast for a golf cart?

Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.

How do you convert a 36V golf cart to 48V?

It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage). When DC power is discussed, amperage equals torque and voltage equals speed.

How do you remove the speed limiter on a electric golf cart?

Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.

How does a golf cart governor work?

By mechanically pulling the throttle lever back, you decrease the gas flow to the engine and control the golf cart's speed. This governor can be adjusted by adjusting the cable nut which holds the cable to the throttle lever.

How do you change the governor on a EZ Go TXT?

Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.

Why is my gas golf cart slow?

Low Battery

Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.

How do I get more torque out of my gas golf cart?

Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.

How fast do most golf carts go?

What is the Average Golf Cart Speed? The average top speed of a typical golf cart without any upgrades is between 12 and 14 miles per hour. Without any sort of modification or upgrade on a golf cart, the top speed that you will be getting on a golf cart is about 14mph.

How much air pressure do you put in golf cart tires?

These tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.

How fast will a gas golf cart run?

A gas cart can run up to 18 - 20 mph and there are not many speed upgrades you can do to one. In addition, electric carts will get up to top speed faster as well.

How do I make my EZ Go text faster?

6 Ways You Can Make a Golf Cart Faster

1. Add More Torque to Your Golf Cart.
2. Upgrade Your Golf Cart's Motor.
3. Improve the High-Speed Controller of the Cart.
4. Add Better Golf Cart Tires.
5. Use a Higher Powered Golf Cart Battery.
6. Watch the Weight in Your Golf Cart.

How many miles will a 36 volt golf cart go?

A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.

How fast is a 36 volt golf cart?

Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires - You can purchase larger tires.

Why does my golf cart only run with the choke on?

Cart Runs Only When Choke is On

This is normally due to a blockage in the fuel line. Another cause is the accumulation of dirt or other debris in the carburetor. To fix this issue, check for any blockages in the fuel line and other engine components.

Why does my ezgo backfire?

The golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the scale is out of adjustment and, in turn, stops the vessel from closing when the microswitch makes contact with the ignition.

Why do I have to choke my golf cart?

A golf cart choke is commonly used when starting a cold engine to restrict air flow while the fuel gets to the engine. Once the mixture stabilizes and the engine can run on its own without air restriction, the choke is released.