Why is my ezgo golf cart so slow?

Low Battery

How can I make my EZ Go faster?

One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.

What causes a golf cart to slow down?

Perhaps the most common reason that a golf cart slows down is when it doesn't have enough power output from your battery. Often, this occurs if the battery pack charge is too low and your cart is out of power. However, if your cart is fully charged and has no problems there, the voltage output may be to blame here.

How do I adjust the speed on my EZ Go golf cart?

Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.

What controls the speed of a golf cart?

Essentially, your golf cart's speed controller sends its current and battery voltage to its motor. This process depends on your golf cart's input device, which includes its throttle. That's how your golf cart's speed controller lets you operate its acceleration rate, as well as its deceleration rate.

How can I speed up my 36V golf cart?

How to Make a 36 Volt Golf Cart Faster

1. Remove any unnecessary additions, racks or parts on your golf cart. ...
2. Power-wash your cart. ...
3. Check the shaft under the ignition pedal. ...
4. Put larger tires on the cart. ...
5. Replace any old or worn-out parts that are causing the cart to move slower than it should.

How fast does a 36V golf cart go?

Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires - You can purchase larger tires.

How do you adjust the governor on a EZ Go valor?

How to Adjust the Governor on a Gas E-Z-Go Golf Cart

1. Locate the governor arm mounted on top of the rear axle case underneath the cart. ...
2. Loosen the adjusting locknut on the end of the governor spring. ...
3. Retighten the adjusting locknut.

How do I test my EZ GO speed sensor?

Testing a Golf Cart Speed Sensor

1. Activate the Row/Tow switch. To do this, you must put the golf cart in the “run” position while pushing the cart itself. ...
2. Make sure the three-pin plug is connected to the sensor. To ensure it is connected, with the output of the green wire, place the piercing probe.

Why does my golf cart slow down going uphill?

The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.

Why does my golf cart go slow up hills?

When your electric golf cart struggles on inclines, it means that you have to work harder to lift the front wheels. The cart's batteries interfere with its acceleration, and your speed decreases. Whether your coach is slowing down or not going up hills at all, you are losing valuable time and effort.

Is 30 mph fast for a golf cart?

Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.

How fast can an ezgo golf cart go?

Looking at the specifications for EZ Go electric golf carts, you notice a cart with a 36-volt motor is capable of 12 to 14 mph top speed. In addition, you notice a cart that's powered by a 48-volt motor can reach speeds just below 20 mph.

How many miles will a 36 volt golf cart go?

A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.

How fast can a golf cart go without a governor?

Consider Replacing Your Speed Control

A typical electric cart without an upgraded speed control tops out around 12 mph. If you go this route, anticipate an upgrade cost around $700.

How do you make a gas golf cart go faster?

Increase the RPM

For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model. For an electric golf cart, several options are available to reach a higher rpm.

How does a governor work on a golf cart?

By mechanically pulling the throttle lever back, you decrease the gas flow to the engine and control the golf cart's speed. This governor can be adjusted by adjusting the cable nut which holds the cable to the throttle lever.

Where is the limiter on a golf cart?

The governor generally sits on top of the engine. This is the easiest way to find the carburetor. Once you've followed the cable up to the governor spring, disconnect it there as well. You can save this cable for later use or throw it away.

How do you adjust the governor on a golf cart?

If you find this rod, then your governor can be easily adjusted by accessing the cart's inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart's governance to increase the overall speed.

Is 48V better than 36V?

Battery Volts

A 36V e-bike battery will allow you to draw a lesser critical current, typically around 15 amperes whereas, a 48V e-bike battery will allow more current in the range of 10 – 40 amperes. It means you can go faster with a 48V E-bike battery.

Can I run 48V on a 36V golf cart?

It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage).

Can a 36V golf cart be converted to 48V?

You can upgrade the battery system by replacing the current batteries with four 12-volt batteries for added power. By having a higher amp-hour rating on the larger batteries, you can avoid more recharging times for the cart.

Why does my electric golf cart go so slow?

Low Battery

Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.